Repairs · Hillsboro, OR
HVAC Repair in Hillsboro
Compare licensed HVAC repair pros in Hillsboro, OR. Typical repair tickets run $150–$600.
8 pros rankedLicense-verifiedWritten estimates
On this page
Common HVAC repairs in Hillsboro
- Heat pump not cooling on humid summer days — low refrigerant, frozen coil, or failing capacitor.
- Furnace short-cycling in winter — dirty flame sensor, oversized equipment, or thermostat miscalibration.
- AC blowing warm air — condenser-fan failure, tripped high-pressure switch, or refrigerant leak.
- Uneven temperatures room-to-room — failing zone damper, duct leakage, or blower-motor issue.
- Loud banging, squealing, or grinding from the air handler — bearings, belt, or blower-wheel imbalance.
- Thermostat shows the right setpoint but the system won't start — control board, transformer, or wiring fault.
- Water pooling at the air handler — clogged condensate drain or cracked pan.
- Frozen evaporator coil that keeps icing over — airflow restriction or low charge.
Ranked shortlist
Request quotes →- Elevate Heating Cooling IncTop pick
What customers say “I contacted Elevate Heating and Cooling because I was sure the compressor in my 21 year old heat pump was bad (or the…”
- O Leary AirTop rated
What customers say “My furnace was not working correctly and I read some great reviews about O'leary air so I contacted them about…”
- Beaverton Heating And CoolingTop rated
What customers say “Great experience, I would recommend this company to my friends and family. I called and got in touch with Jacob from…”
- Pledge Comfort Heating CoolingTop rated
What customers say “When we first contacted these guys I was getting my house ready to sell and needed to replace the furnace as the burner…”
- Petra Heating AcTop rated
What customers say “I don't know about you, but it seems like a rare gem when you find a company that embraces old school values of…”
- Miller Sons Hvac GasTop rated
What customers say “Here’s your revised review following all your requirements: I had a really good experience throughout the whole HVAC…”
- Rubi Heating And CoolingTop rated
What customers say “I had a great experience with Rubi Heating and Cooling. From the first call to the final inspection, their team was…”
What customers say “Our home was built in the 1950s and has a crawl space instead of an attic, which made us worry that installing a new…”
Repair vs replace: quick decision tree
- Age > 15 years — Expect diminishing returns on any single repair. Start pricing replacement in parallel, especially if a second failure in the last 24 months.
- Repair cost > 50% of replacement — A $2,500 repair on an $8,000 system rarely pencils. Run the 5-year math: repair cost + likely follow-on failures vs new-system financing.
- Uses obsolete refrigerant (R-22) — R-22 is phased out; refills are both expensive and short-lived. Replacement is almost always the right call.
- Failed a major component (compressor, heat exchanger) — These are “the system”. A compressor on a 12-year-old condenser is a replacement signal, not a repair.
Typical repair cost range
Hillsboro repair range$150 – $600per repair visit
Diagnostic fees typically run $85–$150 and are often credited toward the repair. Simple swaps (capacitor, ignitor, thermostat) land at the low end; major component replacements (blower motor, control board) push toward the high end.
Estimate your Hillsboro repair
Pick the repair type and your system's age for a ballpark range. Real quotes vary by part availability and diagnosis — use this as a sanity check before approving work.
Frequently Asked Questions
How long does a typical HVAC repair take in Hillsboro?
Most diagnoses take 30–60 minutes on site. Small repairs (capacitor swap, thermostat, ignitor) finish the same visit. Parts-on-order repairs can push the job 1–5 business days depending on supplier stock.
Do repairs come with a warranty?
Labor warranties of 30–90 days are common; parts usually carry the manufacturer's warranty (1–10 years). Always get the warranty terms in writing on the invoice before the tech leaves.
How do I avoid common repair scams?
Red flags: no written estimate before work starts, refrigerant refill with no leak search, blanket recommendation to replace without an inspection, or very high "after-hours" pricing on a non-emergency call. Two written quotes for any repair over $600 is the fastest sanity check.
When should I replace instead of repair?
When the repair estimate exceeds 50% of a new system, or the unit is past 15 years, or it uses obsolete refrigerant (R-22), replacement usually wins the 5-year math. Otherwise repair is almost always the better call.
Licensing verified weekly. Reviews refreshed within the last 30 days.
Licensing data: Oregon Construction Contractors Board (CCB) plus Building Codes Division (BCD) for mechanical trade · Company data: verified business records + Google Business profile
See our editorial standardsReport inaccurate info about HVAC repair in Hillsboro
Get Hillsboro repair quotes
Two or three written quotes is the fastest way to normalize a repair bill — we'll connect you with top-ranked local pros.